Generator Service and Repair Vaal Triangle
Did your generator stop working just when you needed it? Has load shedding taken its toll on your generator? Have you had your generator serviced recently? A Solar Powered Pros partner can repair your generator or service your generator preventing future breakdowns and repairs. Our partners Specialize in:
- Electrical and Mechanical Generator Repairs
- Maintenance and Repair of Petrol and Diesel Generators
- Maintenace and Repair of both Single and Three Phase Generators
If you need your generator to be serviced or repaired contact Solar Power Pros today and we will connect you with a leading Generator Expert in Vaal Triangle
Typical Generator Failures
Faulty or Damaged Wiring
Wiring may rust, fray, or even become cut. Wiring damage requires urgent repair, which shouldn’t be put off. Low voltage alerts, malfunctioning gauges, and tripped breakers are some of the symptoms of poor wiring. Damaged wiring also increases the risk of electrocution and poses a fire risk.
Fuel Failures
Fuel problems often lead to generator repairs. Many fuel failures are due to contamination from the fuel tank itself. When they are drawn into the system, algae, insects, and silt can impair performance and block fuel lines and carburettors.
Burnt Components
Electrical components, motors, circuit boards, transfer coils, and other components may be subjected to incredibly high temperatures during generator operation. Exposure to high temperatures can harm these components and result in problems.
Engine Failure
Engine failure is more likely to occur when maintenance is neglected or performed improperly. The most common reasons for engine breakdowns are using the wrong oil or using it for too long. Failures of the ignition system that result in spark loss frequently occur in smaller engines.
Bad Belts
Belts often get worn, crack or torn with age or incorrect alignment. Generator failures due to belt failures are more common in larger generators where the energy from the combustion engine is transferred to the generator via a belt. Damage belts should be replaced when noticed to prevent failure due to belts.
Dead Batteries
To ensure dependable restart during a power outage, batteries should be changed every two to three years. As a reliable startup cannot be guaranteed with a battery older than 3 years, one should not wait past that point to replace it.
Leaks in the Coolant System
Overheating due to leaking coolant and low coolant levels are quite common as coolant system inspections are often overlooked
Burnt Coils
Generators commonly experience coil failure, which prevents them from producing any power or only a small amount of power even when the engine is operating normally.
It does not matter what type of breakdown you have, our partners can have the problem fixed in no time at an affordable rate.
On-Site and Off-Site Generator Maintenance and Repairs in
On-Site Repairs:
Off-Site Repairs:
Benefits of maintaining and servicing your generator regularly
Let’s look at some of the advantages of maintaining your generator correctly.
Ensures that it functions reliably
You don’t want your generator to fail when you need it most. Servicing your generator ensures that it is ready for use when you need it.
Prevents Fuel blockages and other fuel-related problems
A Generator’s fuel system should be inspected frequently, the fuel tank should be cleaned and the filters should be replaced periodically. Any damaged fuel lines should also be replaced.
Your Generator’s lifespan is vastly improved
If you keep up with the maintenance of your generator, you’ll save a lot of money. Neglecting maintenance obligations might lead to costly repairs. If you don’t maintain your generator, it will also stop working. As a result, if proper maintenance is not carried out, its lifespan will be compromised.
Uses less fuel to provide the same amount of electricity
Regular maintenance enables a generator to run at its most effective level. If you possess a generator, it would be in your best interest for it to be as efficient as possible. A proper maintenance programme ensures it.
Saves you money as it will require fewer repairs
As was noted earlier, skipping maintenance duties will lead to costly repairs. Even if you would have temporarily saved some money, the repairs will cost a lot more in the long run. Being proactive will assist you in avoiding wasting resources on unnecessary repairs.
Simply purchasing and installing a generator is not enough. You have to take good care of it to make sure it runs perfectly. Service your generator before a problem arises.
Generator Maintenance schedule for generators used regularly
WIth Load-shedding ever on the increase and generators operating more frequently our partners recommend the following maintenance schedule.
Monthly checkup that consists of:
- Clean Generator for inspection
- Check oil and coolant levels
- Check Fuel Filters and Empty Water Traps
- Inspect Belts and Tensioner Pulleys
- Test Battery
- Check for any other abnormalities or leaks
- Visual inspection of electrical connections and the control panels
Quarterly service that consists of:
- All of the previous mention tasks
- Fuel filter and oil filter replacement
- Oil and coolant replacement
Annual Major service that consists of:
- All of the previously mentioned monthly and quarterly tasks
- In-depth inspection of fuel system
- Inspection and cleaning of fuel tank
- Valve clearance check and adjustment if required
We advise performing a complete annual service on your generator initially, followed by the regular maintenance schedule moving forward if you haven’t serviced it in a while or it’s your generator’s primary service.
frequent asked questions
Why Choose a SOLAR POWER PROS partner to Repair your Generator??
Are you unsure about who to call to get your generator serviced or fixed? By screening Generator Repair and Service experts all around South Africa and choosing the best to work with us, we have made the decision process simple. Our partners:
Benefit from these advantages today by contacting Solar Powered Pros
How much does it cost to service or repair a generator?
Generator Repair Prices
Depending on the issue the generator has, its size, the cost of the spare parts, and whether the repair was carried out on-site or in a partner’s workshop, the cost of fixing a generator can range from R650 to R10000 or more.
Depending on where you are and whether it is after-hours or not, a standard call-out price for on-site generator repairs can be anywhere from R650 to R1500+. This includes the first hour of labour.
Normal hourly fees for repairs range from R350 to R1000 per hour, depending on whether they are done on-site or in the workshop, and whether it is during regular business hours or after hours. You will also be charged for any spare parts used for the repair
Generator Servicing Prices
The monthly inspection of a generator will range from R300 if performed at a partner’s workshop or R650 when performed on-site.
A standard quarterly service will range from R650 if performed at a partner’s workshop or R1500+ when performed on-site.
A yearly Major service will range from R1000 when performed at a partner’s workshop or R1800+ when performed on-site
All these prices will be affected by the size, type, brand, fuel type and location of the generator.
For the best in Generator repairs and servicing call Solar Powered Pros today and we will connect you with a leading expert in Vaal Triangle.
